HMGA Water Project
  • Home
  • Project Overview
    • Project Description
    • Project Team
    • Collaborative Projects
    • FAQ
  • Publications
    • Blog
    • Factsheets
    • News Articles
  • Events
  • Gallery
  • Dedirting
  • Contact

Lesson Learned: Bottom-up Aerator to Treat Washwater in Settling Tanks

11/11/2014

0 Comments

 
Not every solution implemented results in success. Those various mistakes and failures are discussed here as well as the lessons learned from them.

Goal: Decrease Total Suspended Solids (TSS) while increasing Dissolved Oxygen (DO) concentrations in a settling tank

Solution: Installation of a Bottom-up Aerator.
A Bottom-up Aerator works by pumping compressed air down to a diffuser (Figure 1) situated on the bottom of the tank. The air is released through the diffuser as bubbles which work their way to the surface. As the bubbles rise, the oxygen is dissolving into the water.
Picture
Figure 1: A Bottom-up Aerator diffuser (left) and the surface disturbance caused by the system (right)
Problem: The primary goal of the settling tank is to remove suspended particles by sedimentation and removal of clear water at the surface. The bubbles surfacing from the aerator interrupted this process by keeping the particles in suspension (Figure 2). Also, water testing results showed that there was no significant positive impact on the DO (Figure 3). 
Picture
Figure 2: Total Suspended Solids in a settling tank over time before and after Bottom-up Aerator installation, as shown by the green line
Picture
Figure 3: Dissolved Oxygen concentration in a settling tank over time before and after Bottom-up Aerator installation, as shown by the green line, with a target level of 7-10 mg/L (CCME, 1999)
Discussion: The system failed to increase the DO in the water and had a negative impact on the TSS. While a Bottom-up Aerator is suitable in other situations where particle settling is not a concern, it was not appropriate for resolving this problem. It was removed and replaced with a Surface Aerator.

References
  • Canadian Council of Ministers of the Environment (CCME). 1999. Canadian water quality guidelines for the protection of aquatic life: Dissolved oxygen (freshwater). In: Canadian environmental quality guidelines, Canadian Council of Ministers of the Environment, Winnipeg, MB.
0 Comments

    Project Updates

    Find articles on project-related topics here

    Archives

    December 2016
    October 2016
    September 2016
    July 2016
    June 2016
    May 2016
    April 2016
    March 2016
    February 2016
    January 2016
    December 2015
    November 2015
    October 2015
    September 2015
    August 2015
    July 2015
    June 2015
    May 2015
    April 2015
    March 2015
    February 2015
    January 2015
    December 2014
    November 2014
    October 2014
    September 2014

    Topics

    All
    Aerators
    Coagulation & Flocculation
    Deionization
    Discharge Characterization
    Drum Filter
    Filter Bags
    General Information
    Hydrocyclone
    Lake Simcoe
    Lesson Learned
    Muck
    Nottawasaga Valley
    Pre Treatment
    Pre-Treatment
    Sampling
    Settling Ponds/Tanks
    South-Eastern Georgian Bay
    System Evaluation
    Treatment Technologies
    Ultrafiltration
    Washing Process
    Water Quality Parameters
    Watershed

    RSS Feed

    Article Titles

    Introduction to
      Watersheds

    Lake Simcoe Watershed
    Nottawasaga Valley
      Watershed
    South-Eastern Georgian
      Bay Watershed
    Water, Water,
      Everywhere?
    The Trouble with Muck:
      Size
    Lesson Learned: Bottom-
      up Aerator to Treat
      Washwater in Settling
      Tanks
    Phosphorus, the
      Environment, and
      Farming
    Nitrogen’s Impact on Air,
      Land, and Water
    Water-borne Pathogens
      and Food Safety
    Defining Dissolved
      Oxygen
    Filter Bags
      Demonstration Site
    Organic Matter
      Breakdown &
      Biochemical Oxygen
      Demand
    Dealing with Cloudy
      Water
    Hydrocyclone
      Demonstration Test
    What IS Muck?
    Demystifying Oxidation-
      Reduction Potential
    News Release
      "Technology
      Investigation: Filter
      Bags"
    Drum Filter
      Demonstration Site
    Decomposing With(out)
      Oxygen
    Flow monitoring
    Lesson Learned: Drum
      Filter Optimization
    Polders & the Holland
      Marsh
    Vegetable Washing
      Process
    ​Dry Soil Removal
    Ultrafiltration &
      Deionization
      Demonstration Site
    News Release
      "Technology
      Investigation:
      Ultrafiltration &
      Capacitive Deionization"
    Progressive Passive
      Filtration
    ​Dissolved Air Flotation
    Clarifying the Solid
      Removal Process
    Factsheet Reading Order
    News Release:
      "Technology
      Investigation:
      Coagulation &
      Flocculation"
    Self-Indexing Filter
    Monitoring Discharge
    ​  Flows
    Settling Soil
    Mass Loading
      Calculations
    Lesson Learned:
      Technology Selection
    Electrocoagulation
    Auto-Samplers
Powered by Create your own unique website with customizable templates.